climate change > features > special report
'biochar' might help ease global warming
SPECIAL REPORTPosted: 17 Mar 2009
'Biochar' might help ease global warming
As multibillion-dollar projects intended to sequester carbon dioxide (CO2) in deep geologic storage continue to seek financial support, the fertile black soils in the Amazon basin suggest a cheaper, lower-tech route toward the same destination. Here David J. Tenenbaum looks at the potential of charcoal, in the form of 'biochar', to help soak up climate-changing gas in the atmosphere.
Scattered patches of dark, charcoal-rich soil known as terra preta (Portuguese for "black earth") are the inspiration for an international effort to explore how burying biomass-derived charcoal, or "biochar," could boost soil fertility and transfer a sizeable amount of CO2 from the atmosphere into safe storage in topsoil.
Although burial of biochar is just beginning to be tested in long-term, field-scale trials, studies of Amazonian terra preta show that charcoal can lock up carbon in the soil for centuries and improve soil fertility.
|Biochar pit. Photo � Jim Richardson
Charcoal is made by heating wood or other organic material with a limited supply of oxygen (a process termed 'pyrolysis'). The products of the pyrolysis process vary by the raw material used, burning time, and temperature, but in principle, volatile hydrocarbons and most of the oxygen and hydrogen in the biomass are burned or driven off, leaving carbon-enriched black solids with a structure that resists chemical and microbial degradation.
Christoph Steiner, a research scientist at the University of Georgia, says the difference between charcoal and biochar lies primarily in the end use. "Charcoal is a fuel, and biochar has a nonfuel use that makes carbon sequestration feasible," he explains. "Otherwise there is no difference between charcoal carbon and biochar carbon."
Charcoal is traditionally made by burning wood in pits or temporary structures, but modern pyrolysis equipment greatly reduces the air pollution associated with this practice. Gases emitted from pyrolysis can be captured to generate valuable products instead of being released as smoke. Some of the by-products can be condensed into "bio-oil," a liquid that can be upgraded to fuels including biodiesel and synthesis gas. A portion of the noncondensable fraction is burned to heat the pyrolysis chamber, and the rest can provide heat or fuel an electric generator.
Pyrolysis equipment now being developed at several public and private institutions typically operate at 350�700�C. In Golden, Colorado, Biochar Engineering Corporation is building portable $50,000 pyrolyzers that researchers will use to produce 1�2 tons of biochar per week. Company CEO Jim Fournier says the firm is planning larger units that could be trucked into position. Biomass is expensive to transport, he says, so pyrolysis units located near the source of the biomass are preferable to larger, centrally located facilities, even when the units reach commercial scale.
Spanish conquistador Francisco de Orellana reported seeing large cities on the Amazon River in 1541, but how had such large populations raised their food on the poor Amazonian soils? Low in organic matter and poor at retaining plant nutrients � which makes fertilization inefficient � these soils are quickly depleted by annual cropping. The answer lay in the incorporation of charcoal into soils, a custom still practiced by millions of people worldwide, according to Steiner. This practice allowed continuous cultivation of the same Amazonian fields and thereby supported the establishment of cities.
Researchers who have tested the impact of biochar on soil fertility say that much of the benefit may derive from biochar�s vast surface area and complex pore structure, which is hospitable to the bacteria and fungi that plants need to absorb nutrients from the soil. Steiner says, "We believe that the structure of charcoal provides a secure habitat for microbiota, which is very important for crop production." Steiner and coauthors noted in the 2003 book Amazonian Dark Earths that the charcoal-mediated enhancement of soil caused a 280�400 per cent increase in plant uptake of nitrogen.
The contrast between charcoal-enriched soil and typical Amazonian soil is still obvious, says Clark Erickson, a professor of anthropology at the University of Pennsylvania. Terra preta stands out, he says, because the surrounding soils in general are poor, red, oxidized, and so rich in iron and aluminum that they sometimes are actually toxic to plants. Today, patches of terra preta are often used as gardens, he adds.
Anna Roosevelt, a professor of anthropology at the University of Illinois at Chicago, believes terra preta was created accidentally through the accumulation of garbage. The dark soil, she says, is full of human cultural traces such as house foundations, hearths, cemeteries, food remains, and artifacts, along with charcoal. In contrast, Erickson says he�s sure the Amazonian peoples knew exactly what they were doing when they developed this rich soil. As evidence, he says, "All humans produce and toss out garbage, but the terra preta phenomenon is limited to a few world regions."
Recent studies show that, although biochar alone does not boost crop productivity, biochar plus compost or conventional fertilizers makes a big difference. In the February 2007 issue of Plant and Soil, Steiner, along with Cornell University soil scientist Johannes Lehmann and colleagues, demonstrated that use of biochar plus chemical amendments (nitrogen�phosphorus�potassium fertilizer and lime) on average doubled grain yield over four harvests compared with the use of fertilizer alone.
Reseachers have come to realize the use of biochar also has phenomenal potential for sequestering carbon in a warming world. The soil already holds 3.3 times as much carbon as the atmosphere, according to a proposal Steiner wrote for submission to the recent UN climate conference in Poznan, Poland. However, Steiner wrote, many soils have the capacity to hold probably several hundred billions of tons more.
Plants remove CO2 from the atmosphere through photosynthesis, then store the carbon in their tissues. CO2 is released back into the atmosphere after plant tissues decay or are burned or consumed, and the CO2 is then mineralized. If plant materials are transformed into charcoal, however, the carbon is permanently fixed in a solid form � evidence from Amazonia, where terra preta remains black and productive after several thousand years, suggests that biochar is highly stable.
Carbon can also be stored in soil as crop residues or humus (a more stable material formed in soil from decaying organic matter). But soil chemist Jim Amonette of the Department of Energy�s Pacific Northwest National Laboratory points out that crop residues usually oxidize into CO2 and are released into the atmosphere within a couple of years, and the lifetime of carbon in humus is typically less than 25 years.
Four scenarios for carbon storage have been calculated by the nonprofit International Biochar Initiative (IBI). The "moderate" scenario assumed that 2.1 per cent of the earth's annual total photosynthesized carbon would be available for conversion to biochar, containing 40 per cent of the carbon in the original biomass. It estimates that incorporating this charcoal in the soil would remove half a billion metric tons of carbon from the atmosphere annually.
Because the heat and chemical energy released during pyrolysis could replace energy derived from fossil fuels, the IBI calculates the total benefit would be equivalent to removing about 1.2 billion metric tons of carbon from the atmosphere each year. That would offset 29 per cent of today�s net rise in atmospheric carbon, which is estimated at 4.1 billion metric tons, according to the Energy Information Administration.
Ordinary biomass fuels are carbon-neutral � the carbon captured in the biomass by photosynthesis would have eventually returned to the atmosphere through natural processes; burning plants for energy just speeds it up. Biochar systems can be carbon-negative because they retain a substantial portion of the carbon fixed by plants.
It is these large numbers � combined with the simplicity of the technology � that has attracted a broad range of supporters. At Michigan Technological University, for example, undergraduate Amanda Taylor says she is "interested in changing the world" by sequestering carbon through biochar.
Under the guidance of Department of Humanities instructor Michael Moore, Taylor and fellow students established a research group to study the production and use of biochar as well as how terra preta might fit into a framework of community and global sustainability. Among other projects, the students made their own biochar in a 55-gallon drum and found that positioning the drum horizontally produced the best burn.
The numbers are entirely theoretical at this point, and any effort to project the impact of biochar on the global carbon cycle is necessarily speculative, says Lehmann. "These estimates are at best probing the theoretical potential as a means of highlighting the need to fully explore any practical potential, and these potentials need to be looked at from environmental, social, and technological viewpoints. The reason we have no true prediction of the potential is because biochar has not been fully tested at the scale that it needs to be implemented at to achieve these predictions."
Still, Steiner stresses that other large-scale carbon-storage possibilities also face uncertainties. "Forests only capture carbon as long as they grow, and the duration of sequestration depends very much on what happens afterward," he says. "If the trees are used for toilet paper, the capture time is very short." Soilborne charcoal, in contrast, is more stable, he says: "The risk of losing the carbon is very small � it cannot burn or be wiped out by disease, like a forest."
As a carbon mitigation strategy, most biochar advocates believe biochar should be made only from plant waste, not from trees or plants grown on plantations. "The charcoal should not come from cutting down the rainforest and growing eucalyptus," says Amonette.
Biochar took a step toward legitimacy at the December Poznan conference, when the UNCCD placed it in consideration for negotiations for use as a mitigation strategy during the second Kyoto Protocol commitment period, which begins in 2013.
Under the cap-and-trade strategy that forms the backbone of the Kyoto Protocol, businesses can buy certified emission reduction (CER) credits to offset their emissions of greenhouse gases. If biochar is recognized as a mitigation technology under the Kyoto Clean Deveopment Mechanism, people who implement this technology could sell CER credits.
The market price of credits would depend on supply and demand; a high enough price could help promote the adoption of the biochar process.
The possibility that the United Nations will give its stamp of approval to biochar as a climate mitigation strategy means the ancient innovation may finally undergo large-scale testing. "The interest is growing extremely fast, but it took many years to receive the attention," says Steiner. "Biochar for carbon sequestration does not have strong financial support compared to carbon capture and storage through geological sequestration. [However,] biochar is much more realistic for carbon capture."
This is a shortened version of an article which first appeared in Environmental Health Perspectives Volume 117, Number 2, February 2009
Note: Biocharwatch comments that there is a lot of concern over the promotion of biochar, and also about the claims which biochar advocates are making regarding its impact on soil fertility and soil carbon. It says there is no consistent peer-reviewed evidence to back those claims.
It also poins out that nearly 160 organisations, including Friends of the Earth International have signed a declaration called "Biochar: A new bit threat to people, land an ecosystems": www.regenwald.org. There is also a critical briefing paper called "Biochar for Climate Change Mitigation: Fact or Fiction?" which you can find: here .
To find out more about the potential of biochar see 'Biochar for Environmental Management: Science and Technology'
Edited by Johannes Lehmann and Stephen Joseph. publoished by Earthscan in April 2009 (Hardback �49.95)
Watch a video .
New Scientist interview with James Lovelock